1000kg condensing gas steam boiler

1000kg condensing gas steam boiler

6 ton industrial wood fired 1000kg condensing steam boiler features:

1. Furnace and the two sides of burner zone adopts membrane water-cooled furnace structure. The membrane structure of wood fired steam boiler, our company’s solely design once used in electric boiler , is now applied in shaped assemble boiler. Its advantages lie in great thermal transmission heat, better heat transfer effect, lower heat loss ,better air impermeability, no wall distortion and no ash leakage.

2. The structure of arches adopts the newest technology --the upside”a” technology, which is awarded the national science and technology prize. The front arch is high and short while the back arch is low and long. And the part near the exit is inverse inclined type,while the front arch is 45ºinclined type, they together form a downside a flame structure,which makes the lean coal combustion easier and it can adjust itself to a wide rang of coal types. In this way, the flue gas is kept within the furnace a longer time, and the combustion efficiency is higher. The streamline shaped back arch can throw the non-burned carbon grains in the middle and back part of furnace to the front, so that the coal can be easier to be ignited and the ignition lines are tide.

3. The wood fired steam boiler adopts double layers or single layer layout structure, which can meet the customers’ requirements better.

Recently, the National Energy Board, the Department of Ecology Environment issued "on the issuance of 2018, the provinces (autonomous regions and municipalities) of coal ultra-low emissions and energy-saving targets and tasks" (the "Notice"), called on all localities continued to do over coal low-emission and energy-saving, and promote the development of clean and efficient coal. Ultra-low emissions and to promote energy-saving work in the country has been more than two years, has been established to complete the task of transformation in the eastern provinces, the transformation of the focus shifted to the central and western regions, while the transformation of scope as technology advances and the increasing demand for policy gradually extended.

Under the "notice" requirement, this year nationwide, ultra-low emissions coal power reform objectives and tasks a total of 48.68 million kilowatts, energy-saving goal is to reach 53.905 million kilowatts. In 2016, the capacity of the units involved in the transformation of two to 254.36 million kilowatts, respectively, and 189.4 million kilowatts, good reform bear fruit.

President of the State Power Environmental Protection Research Institute Zhu France and China, said: "By the end of last year, a nationwide ultra-low emissions transformation target task completion rate has reached 71%," ultra-low emissions coal and transformation better, the eastern region has been basically completed, part central provinces ahead of the completion of the task of transformation.

In 2015, the former Ministry of Environmental Protection, the National Development and Reform Commission, the National Energy Board issued "the full implementation of ultra-low emissions and energy-saving programs of work-fired power plant", requires the completion of the eastern part of the overall transformation of ultra-low emissions before the end of 2017, the central region and strive in 2018 years basically completed, the completion of the western region in 2020. "2018 provinces (autonomous regions and municipalities) of coal ultra-low emissions and energy-saving task summary table" (hereinafter referred to as "transformation task list") shows that the eastern provinces have been basically completed the transformation of ultra-low emissions, not published this year transformation capacity unit task. But it is located in the Yangtze River Delta, Jiangsu Province, still issued 1.4 million kilowatts ultra-low emissions and energy-saving renovation target of 900,000 kilowatts.

Zhu France and China, said, "in accordance with the requirements of 2015, Jiangsu has completed the ultra-low emissions and energy-saving target in 2017. However, the new policy will be more units into the transformation range, Jiangsu this year, there is still the task of transformation. In June, the State Council issued a "winning blue sky battle three-year action plan" (hereinafter referred to as "three-year action plan"), required by the end of 2020, more than 65 tons of steam key areas of coal-fired boilers have completed ultra-low emissions and energy-saving. "

It is understood that "three-year action plan" prior to the implementation of energy-saving and environmental protection requirements only for the reconstruction of more than 300,000 kilowatts of conventional units, more than 100,000 kilowatts of power plant owned units. "According to the existing requirements, including Beijing and Tianjin and the surrounding areas, the Yangtze River Delta region and Fenwei plains, including the key areas, more than 65 tons of steam boilers are also included in the scope of the transformation will involve part of 100,000 kilowatts or less captive power plant units and industrial boilers. "Zhu France and China, said," "three-year action plan" in addition to the deadline of 2020, does not provide a specific timetable for the task. Next, the key areas are the provinces in accordance with the requirements of more units, boiler transformation. "

"Task of transformation" table displays, ultra-low emissions transformation capacity this year, mainly in the western region of Inner Mongolia, Shaanxi, Gansu, Xinjiang and so on. In the trend of ultra-low emissions overall speed of the transformation, central Shanxi, Anhui, Henan and other provinces in the region have been completed ahead of the transformation target ultra-low emissions, but energy-saving task still more arduous. Among them, Henan Province this year, energy-saving target capacity of 10.8 million kilowatts, Hunan has reached 9.995 million kilowatts.

Since the ultra-low emission transformation involves the emission of pollutants and other environmental problems, caused by the high social concern. In contrast, concern about energy-saving electric power mainly from the enterprises themselves. Zhu France and China, told reporters, on the one hand is the national energy saving policy requirements, on the other hand also in line with the needs of enterprises to reduce their own costs. At present coal prices continued to run high, coal companies operating pressure, reduce production costs even more urgent demand.

In 2014, the National Development and Reform Commission, the former Ministry of Environmental Protection, the National Energy Board issued "coal upgrading and transformation of energy saving action plan (2014-2020 years)", for energy-saving technology roadmap active coal-fired power units were enumerated, involving the master each link auxiliary equipment, environmental protection equipment and a total of 20 reform measures, in addition to "subcritical unit transformed into ultra (ultra) supercritical units", the rest of the technology have already matured.

In recent years, along with tighter environmental requirements, provide renovation and operation and maintenance services to the rapid development of environmental protection industry. In particular third-party environmental companies, with technical, cost and other advantages, occupy a certain share of power generation enterprise environmental transformation market. But a power industry experts said, is very difficult third-party independent companies to enter the field of environmental protection energy-saving power plant.

"Ultra-low emission increase in the transformation of the original system is new equipment, energy-saving and optimized for major transformation of existing equipment, and boiler plant, steam turbine plant than environmental protection enterprises to understand their own devices." The expert said, "Not only that as systems engineering, energy-efficient coal-fired units involved in the whole process of production, and plant operation economy, is closely related to security, not easily open to third-party companies. third-party companies to enter the energy-saving environmental protection than to enter the market face greater pressure."

Boiler steam temperature affect the safety and economy temperatures above will be lower than the rated temperature of the device, it will have a bad effect. If the temperature exceeds its rated value, the boiler will cause overheating of the relevant metal material, material creep acceleration, will shorten the life of the boiler. If the temperature is too high, but some of the key components of the boiler would cause damage, can also cause serious and even superheater tube rupture. If the temperature is lower than the rated temperature, vapor enthalpy is reduced, increased air consumption, decreased economy. This will reduce the thermodynamic cycle efficiency of the plant, the steam humidity at the last stage blades of the gas turbine increases, causing erosion and damage to water droplets gas turbine blades, affect the safe operation of the gas turbine. Ruoyin with water vapor causes a decrease in temperature, the moisture in the salt impurities formed in the superheater scale, pipe valves, gas turbine blade, because the superheater lead to reduced heat transfer, the temperature decreased, damage increased wall temperature; and cause the valve plug, the operation failure; and a gas turbine blade erosion, loss of balance and vibration occurs. Temperature fluctuations reason superheater actual heat transfer the vapor does not reach the required amount of heat absorbed corresponding balancing. When the heat absorbed is greater than the heat transfer, the temperature rise; conversely decreased. Many factors affect the temperature change, including both gas side and the vapor side. Such as boiler load increased, but also to ensure the boiler load unchanged or decreased in order to prevent pressure shall increase the amount of fuel and air supply, strengthen the burning, causing the furnace exit flue gas temperature of the flue gas volume increases and lower water temperature , temperature increase; If the oil and gas fuel is combusted in the furnace carbon black is not fully formed, into the superheater flue causing secondary combustion, but also greatly increase the superheat temperature. Reducing the temperature of the main reasons: improper adjustment of combustion, low flame center furnace; superheater area is small, or too much leakage at the furnace wall; Save water flow rising or temperature reduction; drum water level or high gas-water separator separating efficiency is lowered, the humidity of the vapor is increased; superheater tube fouling, reduced heat absorption and the like.

When the pressure of the 1000kg condensing steam boiler protection small small steam boiler pressure exceeds the rated boiler steam pressure protection, the need for chain protection: is shutdown, the system stops the combustion; fire mouth can also be varied, single-stage or two-stage combustion, You can adjust the amount of oil, so the buck, to ensure the safe operation of the boiler. Fuel (gas) pressure protection and steam boiler water, as the use of multiple protection: the pressure controller typically use two pressure controller, the pressure signal converted to an electrical signal, the electromechanical converter, the function of the high pressure, or low levels of signal The electrical switching loss, external circuits or automatic control chain protection. Common pressure controller and pressure gauge, vapor pressure overpressure alarm can cut off the burner limit is reached; pressure controller adjusts single fire or dual fire burning the actual operating pressure; for large burner, the pressure may be adjusted according to the size of the size of the amount of fuel, and always maintain a stable pressure relief valve operation is the last line of defense to protect the boiler, the boiler pressure exceeds the limit, according to the set pressure relief valve design feature, the exhaust pressure relief, to ensure the normal operation of the boiler. Temperature protection temperature protection is an important procedure in the safe operation of the boiler, is particularly important for the regulation and protection of the boiler temperature steam; at the same time to regulate protective role in over-temperature hot water boilers. Conventional boiler temperature protection means is a bimetallic temperature controller.

1000kg condensing gas steam boiler Related Information

Oil Fired 1000Kg Hr Steam Boiler - fewo-am-hofteich.de

The 1 ton/hr or 1000kg/hr diesel steam boiler is an 1000kg Diesel Oil Steam Boiler for Food Industry,1ton/hr deisel 1000kg/hr steam boiler,diesel fired steam boiler,steam 50kg 100kg 200kg 300kg 500kg 1000kg 2000kg 3000kg 5000kg 10000kg steam boiler horizontal type (diesel/oil fired, gas fired),1000kg/hr steam boiler,diesel fired steam . Get a Quote

Get A Quote

1000kg steam boiler cost - SRM University

germany 1000kg oil boiler dimensions - ismdr.in Gas Boiler, Steam Boiler, Coal Boiler manufacturer / supplier in China, offering Lsh Model LPG Diesel Fired Steam Boiler 20 Bhp Cost, Small Vertical Steam Boiler 0.5 Ton 500 Kg Hr Spec, Boiler 6000000 Kcal Coal Fired Thermal Oil Heater with Standard Accessories and so on.

Get A Quote

Gas Steam Boilers - eComfort

2020-4-11 · Steam boilers are a common way to heat buildings across the United States, and gas fired steam boilers are the most popular type. Shop our wide selection of gas fired steam boilers from the top manufacturers in the industry.

Get A Quote

gas fired 1ton 1 ton 1000kg steam boiler for sale

1ton Boiler, 1ton Boiler Suppliers and Manufacturers factory direct sale 1ton to 25ton coal fired 3 ton steam boiler with good quality and ISO 1000kg Gas Fired Steam Boiler 1000kg Condensing Gas The top supplying countries are China (Mainland), Hong Kong, and Vietnam, which supply 99%, 1%, and 1% of 1ton boiler respectively. ton boiler products are most popular in Southeast Asia

Get A Quote

energy saving coal steam boiler 1000kg - WHGLA

Energy Saving Coal Steam Boiler 1000Kg. energy-saving coal steam boiler 1000kg - unic.co.in. There are many types of Steam Boiler machine in food industry such coal boiler,biomass boiler and oil boiler,but do you have used condensing gas 1000Kg Steam Boiler machine in food industry.the following is a case of 1000Kg condensing gas steam boiler for food industry in Uzbekistan. 2016

Get A Quote

1000Kg Electric Steam Boiler -

A wide variety of 1000kg hr steam boiler options are available to you, such as free samples. Gas Steam Boiler 1000kg, 1000 kg/h USD Price Coowor.com. Understand Gas Steam Boiler 1000kg, 1000 kg/h USD Price information in Henan Yuanda Boiler Corporation Ltd company, and quickly obtain the latest quotation, select more quality Boiler .

Get A Quote

gas fired 1ton 1 ton 1000kg steam boiler for sale

1ton Boiler, 1ton Boiler Suppliers and Manufacturers factory direct sale 1ton to 25ton coal fired 3 ton steam boiler with good quality and ISO 1000kg Gas Fired Steam Boiler 1000kg Condensing Gas The top supplying countries are China (Mainland), Hong Kong, and Vietnam, which supply 99%, 1%, and 1% of 1ton boiler respectively. ton boiler products are most popular in Southeast Asia

Get A Quote

Gas Steam Boilers - eComfort

2020-4-11 · Steam boilers are a common way to heat buildings across the United States, and gas fired steam boilers are the most popular type. Shop our wide selection of gas fired steam boilers from the top manufacturers in the industry.

Get A Quote

1000kg biomass boiler cost - concoursdecartoon.be

1000kg Electric Steam Boiler - andrepeeters.be. 1000kg biomass boiler - hotelselvaganapathysnest.in. gas fuel 1000kg Steam Boiler - electricheatingboiler.com. 1000kg electric steam boiler Wood Processing Industry ´╗┐Electric Steam Boilers 8-1000kg/hr steam capacity 6 the fuel is, the pressure is /horncob fired boiler for sales 12ton/hity gas fired boiler for sale best gas boilers 2015

Get A Quote

What is a Condensing Gas Boiler? U.S. Boiler Company

Making a wise choice about a new boiler can help you cut your homes heating bill. But, what is the difference between a condensing gas boiler and non-condensing boiler? Which boiler is most efficient? And which one is right for your home?

Get A Quote

1500Kg H Industrial Steam Boiler - Het Koerhuis in Epen

500Kg H Gas Fired Steam Boiler Best Price. 500kg 1000kg 1500kg Industrial Electric Steam Boiler Factory Price Application. Electric steam boiler is hot product, Sitong boiler company export 1.5t/h electric steam boiler to Ethiopia, the elctris steam boiler is used in university kitchen, and according to customer's requests, Sitong engineer design the electric steam boiler with high

Get A Quote

Oil Industry Condensing Steam Boiler Machine

oil industry condensing steam boiler machine seller. Gas Fired Condensing Steam Boiler Machine Seller condensing gas 1000Kg Steam Boiler machine in food industry posted:2018-11-13 There are many types of Steam Boiler machine in food industry such coal boiler,biomass boiler and oil boiler

Get A Quote

1000kg biomass boiler cost - concoursdecartoon.be

1000kg Electric Steam Boiler - andrepeeters.be. 1000kg biomass boiler - hotelselvaganapathysnest.in. gas fuel 1000kg Steam Boiler - electricheatingboiler.com. 1000kg electric steam boiler Wood Processing Industry ´╗┐Electric Steam Boilers 8-1000kg/hr steam capacity 6 the fuel is, the pressure is /horncob fired boiler for sales 12ton/hity gas fired boiler for sale best gas boilers 2015

Get A Quote

energy saving coal steam boiler 1000kg - WHGLA

Energy Saving Coal Steam Boiler 1000Kg. energy-saving coal steam boiler 1000kg - unic.co.in. There are many types of Steam Boiler machine in food industry such coal boiler,biomass boiler and oil boiler,but do you have used condensing gas 1000Kg Steam Boiler machine in food industry.the following is a case of 1000Kg condensing gas steam boiler for food industry in Uzbekistan. 2016

Get A Quote

1000 kg gas boiler - animalhealingtrust.org.uk

1000 kg/h steam boiler Biomass Burn Boiler supplier. series boiler is horizontal type water tube chain grate coal biomass fired steam boiler. the steam capacity is 6-40t/h.Gas Steam Boiler 1000kg,1000 Kg/h Usd price boiler 1000 kg hr best boiler for saleprice boiler 1000 kg

Get A Quote

DO YOU HAVE QUESTIONS? WE ARE HERE TO HELP YOU!